M50 turbo runs extremely rich

[boosteddirty]

Blows black/grey smoke, extreme scent of fuel
My setup:

-10 fuel lines
-10 fuel rail
Aeromotive fpr
Aeromotive A1000 pump
20 gallon fuel cell
60lb injectors
Ngk BKR6EK spark plugs
Miller WAR chip

What could be the problem??

[SamE30e]

Blows black/grey smoke, extreme scent of fuel
My setup:

-10 fuel lines
-10 fuel rail
Aeromotive fpr
Aeromotive A1000 pump
20 gallon fuel cell
60lb injectors
Ngk BKR6EK spark plugs
Miller WAR chip

What could be the problem??

Idle only? WOT? Partial load?

What's your fuel pressure, are the injectors scaled properly?

Sam

[sayed ali]

Miller WAR chip

[nando]

fuel system seems a bit overkill. what fuel pressure are you running?

you have a wideband, don't you? also, if you have a WAR chip, you'd probably be using that wideband to tune it right? :)

[Q5Quint]

Is your war chip tuned properly for 60lbers? What fuel pressure was it tuned with? What fuel pressure do you have?

Are the cold start settings too rich, ie the problem goes away when the car warms up?

Is the turbo map set for a certain boost? I dont think the WAR has a boost sensor so it wouldnt know if your at 0psi or 18psi. If the idle setting on your throttle body isnt working it may think you are cruising/boosting instead of idling and dumping in extra fuel?

[boosteddirty]

Thanks a lot guys i appreciate it. The problem was the fuel rail. I replaced it with a 8an rally road fuel rail. And the war chip is ok, for now. Now I'm having elbows blowing off from boost ;D