The MR E30 Project Thread

[benyen soljax]

Just wasted a lot of time reading your epic thread. I may have done some things differently (who cares?) but all in all I think your E30 found a good home. You are an approved E30 Caretaker.

[MR E30 325is]

March 2nd, 2013

Much much more happened today in my garage than I had originally planned!

Jalves lended a hand and lots was accomplished E30 related.

I picked up the reinforced subframe and transmission and we kicked things off.



I was finally able to install the first part I bought for this build. E36 rack went in without an issue.

A slightly closer view of the beautiful rack and the treehouse lollipops.



This was the highlight of the day!!





And at the end of the night this is how I left it. I am thinking there is roughly ten hours of work left before it is on the road again, which is a lot closer than I thought!!



This thing is going to be incredible to drive.

Tons of little things to do. Almost there!!

[JK_E30]

Pics or the AKG shifter didn't happen.. :D

[Jalves619]

Needs more burnout vids.

[MR E30 325is]

The transmission in the XJ took a shit on me, so as soon as my giubo arrives this fucker has to get back on the road.

Loads of work was put in tonight. It is getting very very close to being completed.

[Jurt]

Where did you get your exhaust dump? It looks like good quality. Everything else looks awesome, Keep it up!

[MR E30 325is]

Race Ready Performance is where I ordered the dump valve from.

Lifetime warranty and extremely rugged and solid design.

March 7th, 2013

In other news

It fucking started!!

After 9 revolutions this bad bitch fired up and rumbled like the monster that it is. No exhaust (due to the guibo not showing up in time). I was surprised at how well everything went.

Giubo will be here tomorrow and the intake elbow will arrive on saturday. After those two parts arrive I can finally drive my E30 around town. It has been far too long.

Videos soon!

[MR E30 325is]

March 8th, 2013

I know there are a few of you out there that still dont completely hate this car, so I did this to solidify your disgust for this E30.

Enjoy!



Final two parts arrive tomorrow. I am going to shovel my whole driveway so I can finally drive this thing.

Hooked up the subwoofer this afternoon before work. I forgot how much I love extremely loud music/bass in a tiny car.

Elation at its max describes my life right now.

[MR E30 325is]

March 9th, 2013

After an exciting chase through my neighborhood to find the mailman who had left the note about my package, i was finally able to install the last difficult piece of the build.

There is a lot going on down here. Super solid. Everything torqued to spec.



This is how it currently sits, less than 24 hours away from finally leaving the garage (after I shovel far too much snow out of its way) and propelling my ass around town.



Until tomorrow!!

[ian e30 318is]

Hell Yes! except for the rear windshield lol

[MR E30 325is]

March 11th, 2013

I drove it around the neighborhood (OMG it hauls so much ass relative to what I have been driving these past 5 months)

Throwing a 1216 code, so I ordered a new TPS. Arrives today. I havent driven it for more than three minutes due to the code and the chopp idle/low rpms, but hopefully that will change today.

Likers gonna like. And to everyone else, too bad. I didnt build this thing for you.

[Dj Buttchug]

Likers gonna like. And to everyone else, too bad. I didnt build this thing for you.

This car is nasty. Buttchug approves :up:

[MR E30 325is]

Thanks DJ.

I am having this issue where the steering wheel shacks back and forth viciously whenever the car is running and I move the steering wheel just a little bit. It will only stop once I shut the engine off. It wont do it again if I start it unless I touch the wheel.

Plenty of fluid. Turning the steering wheel quickly with the car off results in it binding up.

Any suggestions??

Also, Still have the 1216 (TPS potentiometer) code, even with a brand new TPS. After about 30 seconds since start up, rpms will drop and it will idle like shit and billow lots of smoke out of the tailpipe

Any ideas?

[benyen soljax]

There could be something wrong with the power steering pump, causing pulses in the pumping fluid which then translates up to the steering wheel. I am sure you have done this but I would also check the front wheels to make sure there is no damage causing a huge imbalance. I haven't dealt with this issue on E30's, but just taking from my engineering background...

[MR E30 325is]

The pump worked just fine before the rebuild.

This happens when the car is not moving, parked in the garage. It does it when the wheels are both on and off the ground.

The rack is a brand new rebuilt unit.